Horizon Air

De Havilland DHC-8-100 (Dash-8)

Shortly after takeoff from Seattle-Tacoma Intl Airport, the crew noted a right engine power loss and decided to return for a precautionary landing. After lowering the landing gear, a massive fire was discovered in the right engine nacelle. After landing, directional control and all braking were lost. The aircraft departed the left side of the runway 16L after the left power lever was moved to flight idle. The f/o advised tower that the aircraft was out of control. The aircraft rolled onto the ramp area where it struck a runway designator sign, ground equipment, and jetways B7 and B9. The aircraft was subsequently destroyed by fire. Investigation revealed that during overhaul the high pressure fuel filter cover was improperly installed on the engine and the improper installation was not discovered drg company installation of the engine on the aircraft. This led to a massive fuel leak and the nacelle fire. The fire/explosion caused the loss of the engine panels, reducing the effectiveness of the fire suppression system and allowing other systems to be damaged.

Swearingen SA227 Metro III

Check pilot was conducting captain proficiency check on another company pilot (pic) under dark night conditions. Subsequent to full stop landing on runway 25, takeoff checklist was recited. PIC commenced takeoff on runway 07. Check pilot simulated V1 engine cut after liftoff. PIC was unable to accelerate to V2, climb, or maintain directional control. Aircraft levelled off, air speed began to decay and aircraft drifted to the right. Check captain failed to take control or terminate engine cut simulation as evolution deteriorated. Aircraft collided with ILS glideslope tower marked by red obstruction lights. Loss of control followed when right wingtip/aileron separated. Aircraft then impacted ground and slid to a stop. Takeoff flap position should be 1/4. Both flaps found near 1/2 flap extended position. Handle found in 1/2 flap detent. Performances charts show aircraft able to reach V2 at 50 feet altitude in 6,500 feet roll, then +575 fpm climb (vyse) at acc wt.