Boeing 767-200

Dynamic International Airways

On October 29, 2015, about 12:33 pm eastern daylight time (EDT), Dynamic International Airways flight 405, a Boeing 767-200ER, N251MY, experienced a fuel leak and subsequent fire while taxiing for departure at the Fort Lauderdale-Hollywood International Airport, Florida (FLL). Of the 101 passengers and crew onboard, one passenger received serious injuries. The airplane sustained substantial damage from the fire. The flight was operating under the provisions of 14 Code of Federal Regulations Part 121 supplemental as a scheduled charter from FLL to Maiquetía Simón Bolívar International Airport (CCS), Caracas, Venezuela. A significant fuel leak and subsequent fire occurred in the left engine strut and nacelle during taxi, resulting in substantial damage to the airplane. The fuel leak was the result of a fuel line flexible coupling (Wiggins fitting) loosening and becoming disengaged due to the lack of a safety lockwire on the coupling as required by the maintenance manual. The leaking fuel contacted hot engine case surfaces which ignited the fire. Records indicate that maintenance was conducted on this fitting in October of 2012 at the 4C check prior to the airplane being prepared for storage. The area would also have been subject to a visual inspection when the airplane was brought out of storage in 2015. The same maintenance facility conducted both of these activities. About 240 flight hours were logged between the aircraft returning to service and the accident. The leak occurred after the coupling loosened due to the missing safety wire which was the result of an error by the third-party maintenance provider. The flight crew promptly shut down the left engine using the fire handle, and requested fire equipment. As the airplane stopped on the taxiway, passengers saw the fire and insisted that the cabin crew initiate an evacuation. One passenger opened an overwing exit on his own, and the slide did not deploy. The cabin crew initiated the evacuation without coordination with the flight crew. After the evacuation had already begun, the flight crew advised over the PA to evacuate out the right side of the airplane. The flight crew did not immediately shut down the right engine and an evacuating passenger ran behind the engine and was blown to the pavement resulting in serious injuries. The lack of coordination between the flight crew and cabin crew resulted in the evacuation initiating while the right engine was still running.

ABX Air

On June 28, 2008, about 2215 Pacific daylight time, an ABX Air Boeing 767-200, N799AX, operating as flight 1611 from San Francisco International Airport, San Francisco, California, experienced a ground fire before engine startup. The captain and the first officer evacuated the airplane through the cockpit windows and were not injured, and the airplane was substantially damaged. The cargo flight was operating under the provisions of 14 Code of Federal Regulations Part 121. At the time of the fire, the airplane was parked near a loading facility, all of the cargo to be transported on the flight had been loaded, and the doors had been shut.

All Nippon Airways

On June 26, 2002, a Boeing 767-200 of All Nippon Airways, registration JA8254, took off from Shimoji-Shima Airport at around 11:32 on a flight for takeoff and landing training. The flight plan of the aircraft submitted to the Shimoji-Shima Airport Office of the Japan Civil Aviation Bureau (CAB) was as follows: FLIGHT RULES: VFR, AERODROME of DEPARTURE: Shimoji-Shima Airport, TIME: 11:20, CRUISING SPEED: 250kt, LEVEL: VFR, ROUTE: Traffic Pattern, DESTINATION AERODROME: Shimoji-Shima Airport, FLIGHT PURPOSE: Training Flight, TOTAL EET: 1 hour 40 minutes, ENDURANCE: 6 hrs 32 minutes, PERSONS ON BOARD: 3. The three persons on board were in the cockpit at the time of the accident: A pilot undergoing training for promotion to First Officer (Trainee Pilot-A) occupying the left pilot’s seat, the Captain acting as instructor occupying the right pilot’s seat, and another pilot undergoing training for promotion to First Officer (Trainee Pilot-B) occupying the left observer’s seat. First, Trainee Pilot-B made seven landings on runway 17 from the left pilot’s seat, including two landings with one engine simulated inoperative, and a go-around with both engines operative. He then changed places with Trainee Pilot-A. At around that time, the wind direction changed from the south to the west, and the aerodrome control tower instructed a change to runway 35. Trainee Pilot-A then made two landings on runway 35 with both engines operative, and training then switched to landing with one engine simulated inoperative. The first landing was made with the left engine simulated inoperative. After that, during a landing with the right engine simulated inoperative, the touchdown was late and Trainee Pilot-A attempted to go-around with go-around thrust on the left engine only. A few seconds later the instructor increased power on the right engine to go-around thrust, but at that time even though the left engine thrust had started to increase the right engine was still at minimum idle thrust. As a result, a thrust imbalance occurred between the left and right engines while right rudder was being applied, and the aircraft rolled and yawed to the right (East). Although Trainee Pilot-A and the instructor attempted to correct the attitude changes, the aircraft veered off the runway into a grass field on east side of the runway and came to a stop around 1,990m from the point it had first touched down. The accident occurred at runway 35 of Shimoji-Shima Airport at around 12:54.

Air China

On April 15, 2002, about 11:21:17, Air China flight 129, a Boeing 767-200ER, operated by Air China International (Air China hereinafter), en route from Beijing, China to Busan, Korea, crashed during a circling approach, on Mt. Dotdae located 4.6 km north of runway 18R threshold at Busan/Gimhae International Airport (Gimhae airport hereinafter), at an elevation of 204 meters. The flight was a regularly scheduled international passenger service flight operating under instrument flight rules (IFR) within Korean airspace, according to the provisions of the Korean Aviation Act and Convention on International Civil Aviation. One captain, one first officer and one second officer, eight flight attendants, and 155 passengers were on board at the time of the accident. The aircraft was completely destroyed by impact forces and a post crash fire. Of the 166 persons on board, 37 persons including the captain and two flight attendants survived, while the remaining 129 occupants including two copilots were killed.

United Airlines

The Boeing 767 departed Boston-Logan Airport at 0814LT on a regular schedule service to Los Angeles, carrying 56 passengers and a crew of nine. Few minutes later, the aircraft was hijacked by terrorists who modified the flight path and flew direct over New York. At 0903LT, the aircraft struck the South Tower of the World Trade Center, between 78th and 84th floor. The aircraft disintegrated on impact and all 65 occupants were killed. The tower later collapsed. The terrorist attacks of September 11, 2001 are under the jurisdiction of the Federal Bureau of Investigation. The Safety Board provided requested technical assistance to the FBI, and this material generated by the NTSB is under the control of the FBI. The Safety Board does not plan to issue a report or open a public docket.

American Airlines

The Boeing 767 departed Boston-Logan at 0759LT on a regular schedule service to Los Angeles, carrying 81 passengers and a crew of 11. Few minutes later, the aircraft was hijacked by terrorists who modified the flight path and flew direct over New York. At 0845LT, the aircraft struck the North Tower of the World Trade Center, between 94th and 99th floor. The aircraft disintegrated on impact and all 92 occupants were killed. The tower later collapsed. The terrorist attacks of September 11, 2001 are under the jurisdiction of the Federal Bureau of Investigation. The Safety Board provided requested technical assistance to the FBI, and this material generated by the NTSB is under the control of the FBI. The Safety Board does not plan to issue a report or open a public docket.

USAir - US Airways

The aircraft experienced an uncontained failure of the high pressure turbine stage 1 disk in the No. 1 engine during a high-power ground run for maintenance. Because of a report of an in-flight loss of oil, US Airways mechanics had replaced a seal on the n°1 engine’s integral drive generator and were performing the high-power engine run to check for any oil leakage. For the maintenance check, the mechanics had taxied the airplane to a remote taxiway on the airport and had performed three runups for which no anomalies were noted. During the fourth excursion to high power, at around 93 percent N1 rpm, there was a loud explosion followed by a fire under the left wing of the airplane. The mechanics shut down the engines, discharged both fire bottles into the No. 1 engine nacelle, and evacuated the airplane. Although both fire bottles were discharged, the fire continued until it was extinguished by airport fire department personnel. The aircraft was damaged beyond repair.

Ethiopian Airlines

Ethiopian Airlines flight ET961 had taken off from Addis Ababa, Ethiopia, at 08:09 hours UTC for a scheduled flight to Abidjan, Ivory Coast via Nairobi, Kenya; Brazzaville, Congo; and Lagos, Nigeria. Twenty minutes after takeoff, at about 08:29 UTC, one passenger stood up from his seat and ran up the aisle to the cockpit, and two other passengers followed him heading for the cockpit. While rushing to the cockpit one of the men said "Everybody should be seated, I have a bomb!". Then they opened the cockpit door and stormed in. They declared to the pilots that there were eleven hijackers on board and beat the First Officer and forced him out of the cockpit. They then grabbed the fire axe and fire extinguisher bottle from their respective stowages and ordered the pilot-in-command to change direction and fly to Australia. The pilot-in-command explained to the hijackers that he had not enough fuel to reach Australia and demanded to make a refueling stop at Mombasa. The hijackers refused the refueling stop and continued arguing with the pilot-in-command. They insisted that they had learned from the inflight magazine that the B767 could fly 11 hours without refueling. After passing Dar es Salaam one of the hijackers ordered him to fly away from the coast, head to Australia and indicating to the altimeter not to descend below FL390. The pilot-in-command turned left towards the Comoros Island. The lead hijacker was sitting in the first officer's seat and was fiddling with the aircraft's controls, kicking the rudder, whilst also drinking whisky. The pilot-in-command kept on telling them that he was running short of fuel pointing to the fuel quantity indicators, but the hijackers did not listen. The leader continued fiddling with the controls, trying to turn the aileron and pulling the reverse thrust lever at random. As the flight came over the Comoros Islands the pilot-in-command saw the Moroni International Airport runway and circled 15-20 nm south of the field. Then the LOW FUEL CAUTION came on. The pilot-in-command pleaded to land because of low fuel. The hijackers were unconcerned and only insisted that the pilot not descend below FL390. At about 11:41 UTC the right engine ran down to wind milling speed. The pilot-in-command showed the red warning message for the right engine on the EICAS to the hijacker. At this moment, the hijacker left the right seat and went to the cabin door to discuss with the other two hijackers. This gave the captain the opportunity to pick up his microphone and address the passengers: "....ladies and gentlemen this is your pilot, we have run out of fuel and we are losing one engine this time, and we are expecting crash landing and that is all I have to say. we have lost already one engine, and I ask all passengers to react ..... to the hijackers ....". The hijacker then came back to the cockpit and hit the microphone out of the pilot's hand. After the right engine failed, the pilot started to descend the aircraft in order to increase speed, but the hijacker again interfered and violently played with the controls which resulted in improper control inputs. As a result the autopilot was disconnected and the flight became erratic with the airspeed varying between 216 and 336 kts. As the pilot regained control of the aircraft, the left engine went dead. The hijacker kept on instructing the pilot not to descend and again went to the cabin. Upon returning to the cockpit he saw that the altitude was decreasing, and angrily shouted at the pilot not to go any lower. The pilot said that the fuel was already finished and that the engines were without power. This time the hijacker instructed the captain not to touch the controls, and threatened to kill him. The captain said, "I am already dead because I am flying an airplane without engine power." The first officer, who had earlier been forced out to the First Class cabin, got up and, via the right aisle, went to the rear of the aircraft where he saw that a lot of economy class passengers had their life jackets on and that some had already inflated them. The first officer, along with the cabin crew members, helped the passengers to deflate the life jackets and showed them how the jackets should be re-inflated and how to assume the brace position during impact. While returning to the front of the aircraft, they repeated the same instructions as many times as they could. About less than 2 minutes before the ditching, the co-pilot forced his way to the cockpit shouting "let me help the pilot ...". After adjusting his seat and seat belts the pilot asked him for help since the controls were heavy. The hijackers still kept on struggling with the controls. By now, the aircraft was descending into the Indian Ocean over the Comoros Islands. The aircraft now had only standby instruments and RAT (Ram Air Turbine). The altimeter was indicating 150 feet and the airspeed was 200 kts. By this time the flight crew had been left alone to assume control. They turned the aircraft to the left in order to parallel the waves. However, the aircraft brushed the water in a left-wing-low attitude. It was then held straight and level after which it broke into four sections and came to rest in the sheltered waters 500 metres off Le Galawa Beach. Of the 175 occupants, 6 crew members and 119 passengers were fatally injured in the accident. Six crew members and 38 passengers sustained serious injuries, 2 passengers sustained minor injuries and 4 passengers received no injury.

TACA International Airlines - Transportes Aéreos Centro Americanos

The approach to Guatemala City-La Aurora Airport was completed in poor weather conditions with rain falls, a visibility of three miles below a 2,000 feet cloud ceiling. The crew was cleared to land on runway 19 with a tailwind component as the wind was from 030° at 8 knots. The aircraft landed 1,070 metres past the runway threshold (runway 19 is 2,763 metres long) at a speed that was 17 knots above Vref. The crew started the braking procedure and thrust reversers were deployed. At a distance of 300 metres from the runway end, the captain decided to veer off runway to the left. At a speed of 90 knots, the aircraft went through a perimeter fence, down an embankment and eventually came to rest into several houses. All 236 occupants evacuated safely while the aircraft was damaged beyond repair. Three people on the ground were slightly injured.