Critical Air Medicine

Cessna 421C Golden Eagle III

During takeoff climb, the twin-engine airplane encountered a strong downdraft and impacted trees and terrain. The pilot reported that while taxiing to the runway, he scanned the sky with the monochrome weather radar, which was set at the 40-mile range. 'No weather was shown behind the runway and a cell was shown 15 miles from the runway.' The takeoff roll was 'uneventful,' and the airplane was rotated at 95 knots. Climb out was accomplished at 110 knots, the engines were at maximum power, the propellers at maximum RPM, and the manifold pressure was indicating maximum. A 10-degree turn towards the Cotulla VOR was being made when at 1,500 feet msl, a sharp descent was felt with the VSI indicating an 800 ft/min rate of descent. The wings were leveled and the airspeed was slowed to 85 knots. 'The rate of descent slowed to 400 ft/min and then finally to 300 ft/min until impact...' The airplane was destroyed by fire that erupted on impact. A review of doppler weather radar images showed thunderstorms in the vicinity of the airport.

Cessna 421C Golden Eagle III

Shortly after takeoff, the pilot reported he had 'a problem' and needed to return immediately. Witnesses observed dark black smoke coming from both engines. The airplane collided with a tree 1/2-mile northeast of the runway threshold. Analysis of fuel samples revealed the presence of approximately 50% jet fuel. The right propeller was found feathered and engine disassembly revealed a hole burned in the right engine number 5 piston. Left engine disassembly revealed piston edges eroded down to the first compression ring. Fuel filler restrictors had been installed in the airplane's fuel tanks, but the fuel truck did not have the restrictive mating nozzle. The fuel truck was owned by the fuel vender and leased to the FBO.

Cessna 421C Golden Eagle III

A Cessna 421 crashed after an inflight breakup. Investigation disclosed that the left outboard portion of the elevator assembly (including the balance weight) separated first, resulting in empennage flutter and subsequent in-flight breakup of the empennage. The left elevator outboard hinge and support structure exhibited evidence of hinge overtravel. The left horizontal stabilizer front spar had failed downward; rivets that attached the left outboard hinge to the rear spar of the left stabilizer had sheared; and the left elevator center hinge had been pulled off the rear spar. About 100 flight hours before the accident, maintenance was performed to repair the left elevator balance weight (which was loose) and to repair a damaged stiffener in the center structure of the horizontal stabilizer. However, when examined after the accident, the balance weight was tight and the repair to the stiffener was intact. All three occupants were killed.